高效液相色谱-串联质谱法测定鸡肉产品中金刚烷胺残留量

应用高效液相色谱-串联质谱法测定鸡肉产品中金刚烷胺的残留量。样品经乙腈提取,以乙腈-水(3+7)溶液作为定容溶液。Phenomenex Kinetex C18色谱柱为分离柱,以不同体积比的0.1%(体积分数)甲酸溶液和乙腈为流动相进行梯度洗脱,采用电喷雾正离子源选择反应监测模式检测。采用基质匹配曲线校正。金刚烷胺的质量浓度在0.005~0.1mg·L-1范围内与其峰面积呈线性关系,检出限(3S/N)为1.0μg·kg-1。以空白样品为基体进行加标回收试验,所得回收率在82.5%~94.0%之间,测定值的相对标准偏差(n=6)在6.3%~11%之间。     

LF-NMR和MRI对干制虾仁复水过程水分状态及品质变化的研究

采用低场核磁(LF-NMR)及其成像技术(MRI)研究干制虾仁在25℃复水过程中的水分含量、分布及状态变化,并通过线性回归分析不同复水时间干制虾仁的LF-NMR参数与质构特性及复水率的相关性。实验结果表明,干制虾仁复水过程中存在结合水、不可移动水和自由水3个组分峰,随着复水时间的增加,结合水无明显变化,而自由水、不易流动水含量增加,且自由度增加,流动性增大。LF-NMR参数(T_(22)、T_(23)、A_(22)、A_(23)和A_(Total))和硬度、咀嚼性、弹性、凝聚性以及复水率有极显著的相关性(R~2≥0.613),为干制虾仁复水过程中品质的快速无损预测提供了一种新方法。     

Effect of ultrasound and chlorine dioxide on Salmonella Typhimurium and Escherichia coli inactivation in poultry chiller tank water

This study evaluated the application of ultrasound alone or combined with chlorine dioxide (ClO₂) for Salmonella Typhimurium and Escherichia coli inactivation in poultry processing chiller tank water. A Full Factorial Design (FFD) 2² was conducted for each microorganism to evaluate the effect of ultrasound exposure time (x₁: 1 to 9 min; fixed: 37 kHz; 330 W; 25 °C) using a bath, and ClO₂ concentration (x₂: 1 to 17 mg L⁻¹) on microorganism count expressed in log CFU mL⁻¹ in distilled water. Variable x₂ had a negative effect on Salmonella Typhimurium (-5.09) and Escherichia coli (-2.00) count, improving the inactivation; while a x₁ increase present no inactivation improvement, explaining the use of x₁ lower level (1 min) and x₂ higher level (17 mg L⁻¹). The best condition for microorganism inactivation based on FFD was evaluated in chiller tank water (with organic matter) at 25, 16, and 4 °C; x₁ was kept (1 min), however x₂ was adjusted to obtain the same residual free chlorine (2.38 mg L⁻¹) considering the ClO₂ consumption by organic matter, achieving the value of 30 mg L⁻¹. An inactivation of 49% and 31% were observed for Salmonella Typhimurium and Escherichia coli. When ultrasound was replaced by a simple agitation in the presence of ClO₂, there was no inactivation for both microorganisms. Moreover, at poultry carcass pre-chilling (16 °C) and chilling (4 °C) conditions, the synergism of ultrasound combined with ClO₂ was more pronounced, with microorganisms’ reductions up to 100%.     

Teil II: Ergebnisse bei der Bestrahlung einzelner Nahrungsmittelgruppen (Zusammenfassender Bericht)

Nachdem im ersten Teil dieser Arbeit [170] einige Grundprobleme der Nahrungsmittelbestrahlung behandelt wurden, sollen nun die bei der Bestrahlung wichtiger Nahrungsmittelgruppen erzielten Ergebnisse dargelet und eine Einschätzung der Entwicklungstendenzen versucht werden.     

Effectiveness of radiation processing in elimination of Campylobacter from poultry meat

Campylobacter, a common poultry intestine commensal, is a well known cause of human gastric illnesses across the globe. Consumption of contaminated poultry meat is a major cause of Campylobacter related infections. In the present study, radiation sensitivity of indigenous strains of C. jejuni and C. coli isolated from poultry was evaluated. The decimal reduction dose (D₁₀) values of different Campylobacter isolates at 0-4 °C in saline and blood broth were in the range of 0.120-0.210 kGy and 0.170-0.234 kGy, respectively. D₁₀ values in chicken meat homogenate for Campylobacter were in the range of 0.110-0.190 kGy. Chicken meat samples were inoculated with C. jejuni and exposed to gamma radiation to study the effectiveness of radiation treatment in elimination of Campylobacter. Radiation treatment with a dose of 1 kGy could achieve complete elimination of 10⁵ CFU of Campylobacter/g in poultry meat samples. No recovery of Campylobacter was observed, even after enrichment and selective plating in 1 kGy treated chicken meat samples stored at 4 °C up to 7 days. Present study shows that irradiation of poultry meat with 1 kGy can ensure safety of poultry meat.     

X射线荧光光谱法测定原煤中氯量

提出了煤粉直接压片制样-X射线荧光光谱法测定原煤中氯量。将粒径小于74μm的原煤粉末经90℃烘干后置于聚乙烯模具中,以4.16 MPa压力制成直径为35 mm的样片,制成的样品保存于干燥器中应尽快进行测定。选用煤标准物质制作氯的测定范围为0.01%～0.11%(质量分数)之间的标准曲线,并建立了集校准曲线、基体校正及谱线重叠校正为一体的回归方程作为方法的定量基础。求得方法的检出限为15μg·g~(-1)。用同一标准物质(ω_(Cl)0.057%)重复测定12次,测得其相对标准偏差为1.85%。用所提出的方法测定了2个煤标准物质,所得结果与认定值一致。     

真空冷却过程中实验条件对真空冷却速率的影响

以熟肉为实验材料,对实验条件对真空冷却速率的影响进行了理论分析和实验研究。实验结果表明:真空室有效容积越小、真空泵抽速越高,则真空冷却时间就会越短;冷阱温度对真空冷却速率有着明显的影响;当真空室内的最终压力在0.4～0.61kPa变化时,熟肉的表面温度一直在0℃以上,其真空冷却的时间随着真空室内压力的升高而增加。而真空室内的最终压力在0.3kPa左右时,熟肉的表面温度在真空冷却过程会低于0℃。     

The Effect of Hemp Cake (Cannabis sativa L.) on the Characteristics of Meatballs Stored in Refrigerated Conditions

Hemp cake, a by-product of cold pressing oil from hemp seeds, is a nutritious ingredient that could be used for the production of new or reformulated meat products. The aim of this study was to determine the influence of inclusion of 0.9%, 2.6%, 4.2%, and 7.4% (w/w) hemp cake (Cannabis sativa L.) on the physicochemical and textural properties, oxidation, and sensory acceptance of cooked and vacuum-packed meatballs during refrigerated storage. The addition of 7.4% hemp cake enhanced the amount of dry matter and reduced the content of water. Lightness (L*) and redness (a*) values reduced significantly with higher levels of hemp supplementation. Regardless of the amount of hemp additive, pH, color parameters did not differ significantly during the 12 days of storage. Hemp cake significantly decreased protein and lipid oxidation: the inhibitory effect of adding 7.4% hemp cake on protein carbonyl group formation and TBARS values reached 11.16% and 36.5%, respectively, after 10 days of storage. Sensory analysis revealed that meatballs prepared with 0.9% and 2.6% hemp cake gained higher overall scores. The results indicate that hemp cake, a material considered mainly as waste, may be destined for food purposes and be an alternative ingredient for the production of sustainable meat products.     

基于高光谱成像的生鲜猪肉细菌总数预测建模方法研究

生鲜猪肉中细菌总数(TVC)超标会直接危害大众,为此研究验证高光谱成像技术结合相应的建模方法预测生鲜猪肉中TVC的可行性。针对非线性、小样本问题, 以及光谱维和空间维的大数据量问题,在综合比较偏最小二乘回归(PLSR)、人工神经网络(ANNs)和最小二乘支持向量机(LS-SVM)3种建模方法的基础上,最终选取了LS-SVM方法组建模型。3种建模方法综合比较的结果表明,LS-SVM同时兼顾了训练精度和泛化能力两方面的性能,使其都能做到最优,与标准平板菌落计数法所检测TVC的决定系数分别为0.987 2和0.942 6,校正均方根误差和预测标准均方根误差分别为0.207 1和0.217 6,其建模性能优于其他方法。研究结果表明,高光谱成像技术结合LS-SVM预测建模方法可作为快速、非破坏预测生鲜猪肉TVC的有效手段。     

基于光谱技术的原料肉新鲜度指标在线检测系统开发及试验

为了实现原料肉新鲜度参数的无损在线实时评估,基于双波段可见/近红外反射光谱（350~1 100和1 000~2 500 nm）技术建立了原料肉新鲜度主要指标的在线检测系统。研究设计了装置的光源单元、光谱采集单元、控制单元和驱动单元,优化设计了光源固定支架和安放角度,编写了相应的控制程序,开发了实验室用和便于在不同生产线应用的两套在线检测系统。首先,对试验参数（传送带速度和样品到透镜入光口距离）进行了优化研究,通过光谱相似度比较和显著性分析,确定传送带速度是275 mm·s-1、距离是12 cm时能够获得更加稳定的光谱信号。然后,基于该试验参数,分别在静止和在线条件下采集了贮藏时间为1~13 d共50个猪肉样本的反射光谱,并利用抛物线拟合法对双波段光谱进行融合,以获取整条覆盖可见及近红外区域的完整光谱。为了使两个波段范围内的光谱数据点权重相同,在整个波段范围内均匀分布,借助三次样条插值法将所有光谱数据点以2 nm为间隔进行重新排布。采用窗口移动多项式最小二乘拟合法对光谱作平滑处理,采用标准正态变量变换对每条光谱进行标准化预处理,分别建立了静止和在线条件下新鲜度主要表征指标-颜色（L*,a*和b*）、pH和挥发性盐基氮的预测模型,以此验证所搭建系统的可靠性。经过对比分析,发现在线条件下的建模结果不如静止状态下的建模结果,这可能与在线采集时光谱存在漂移现象有关。进一步尝试利用一阶导数处理来消除基线漂移强化谱带特征,并对一阶导数和标准化处理顺序对建模结果的影响进行了探讨。结果发现先经过一阶导数再经过标准化处理,能更好地消除外部干扰造成的影响,建模结果更佳。在该处理方式下,基于第一波段光谱建立了颜色参数（L*,a*,b*）的预测模型,基于双波段光谱建立了pH和挥发性盐基氮的在线检测模型,预测相关系数分别为0.955 3,0.924 7,0.955 1,0.961 5和0.966 8。最后,为了验证模型的适用性,基于开发的便于在不同生产线应用的在线检测系统,利用独立的20个样本对在线模型进行外部验证,对颜色参数（L*,a*,b*）,pH和挥发性盐基氮的预测相关系数分别为0.918 9,0.914 1,0.947 7,0.950 4和0.960 6。研究结果表明,该系统通过双波段光谱的实时采集和融合,可以获取更多反应样本内部信息的光学信号,具有更强的检测能力。结合设计的光路等其他硬件单元,可以同时获取样本表面更大区域的反射光谱信息,从而实现对原料肉新鲜度主要表征参数的无损、在线、实时评估。该系统便于组装和拆卸,可以适应不同企业生产线的实际需要,具有较强的实用价值和较好的市场前景。